Material Safety Data Sheet
Material Safety Data Sheet
5S-Road Stabilizer
1. Identification of Substance/Preparation and Company:
Product Name: 5S-ROAD
○
○ Main Use: Road Construction
○ Company: 5S – Sand Soil Stabilization Smart Solutions ,Dammam, Saudi Arabia
2. Composition / Information on ingredients
○ Chemical Nature: Water based dispersion of synthetic polymers with additives
○ Hazardous Components: None according to EU directive 1999/45/EC
3. Hazards identification:
○ Critical hazards to man and the environment: None according to EU directive 1999/45/EC
4. First Aid measures:
○ Eye contact: May cause temporary irritation. Irrigate with water for 15 minutes holding eyelid open. Seek medical attention if irritation persists.
○ Skin contact: Prolonged contact may cause irritation. Remove contaminated clothing. Wash thoroughly with soap and water Seek medical attention if symptoms persist.
○ Inhalation of vapour: Remove to fresh air in severe cases seek medical attention.
Ingestion: May cause nausea. Seek immediate medical attention Do not induce vomiting.
5. Firefighting measures
○ Hazards during fire-fighting: The product is water based and is not combustible.
6. Handling and Storage:
Handling:
○ No special precautions necessary.
○ Observe good housekeeping practice.
○ Keep workplace well ventilated.
Storage:
○ Store between +5°C and +45°C protected from frost and direct sunlight.
○ Do not use storage vessels or pipework made of aluminium, copper or their alloys.
○ Detailed advice on storage systems can be provided.
○ Bulk tanks should be regularly cleaned and sterilized.
Level 21 Khobar Gate Tower |
King Fahad Road | PO Box
32348 Khobar 31952, KSA
www.5S-Tech.Org
+966 13 330 8542
Page 1 of 3
Material Safety Data Sheet
5S-Road Stabilizer
7. Exposure controls / personal protection
○ General protective measures: The product may contain low levels of volatile organic compounds or ammonia which may evaporate during application and drying.
○ Advice on system: Provide good general ventilation in the workplace. Where design the product is dried or sprayed, local extraction is recommended.
○ Components with workplace parameters: none according to EU directive 1999/45/EC
○ Personal protective equipment:
● Respiratory: If spraying product without local exhaust ventilation, protection wear mask respirator with a charcoal cartridge.
● Hand protection: Impermeable gloves recommended.
● Eye protection: Eye protection recommended.
● Skin protection: In case of severe splashing wear waterproof overalls and boots. Wash with soap and water after handling.
● Hygiene measures: Do not eat, drink or smoke when handling product.
8. Physical and chemical properties
○ Physical form: liquid
○ Colour: white
○ Odour: faint aromatic
○ Flash point: not applicable
○ Vapour pressure: 23 hPa @ 20°C
○ Relative density: 1.00 +/-0.1
○ Solubility in water: insoluble but miscible in all proportions
○ pH: 6 +/- 0.5
○ Viscosity: <1000 mPa s
9. Stability and Reactivity
○ The product is stable under recommended storage conditions - see Section 7
○ Incompatible: None
10. Toxicological information
○ Long term experience of this product type indicates no danger to health when properly handled under industrial conditions
11. Transport information
○ The product is not classified as Dangerous for Transport.
Level 21 Khobar Gate Tower |
King Fahad Road | PO Box
32348 Khobar 31952, KSA
www.5S-Tech.Org
+966 13 330 8542
Page 2 of 3
Material Safety Data Sheet
5S-Road Stabilizer
12. Ecological information
○ Degradation/elimination: DOC elimination after 2 days (OECD302B): 98 %
○ The product can be virtually eliminated from water by biotic processes, e.g. adsorption onto activated sludge.
○ Bioaccumulation: No evidence of bioaccumulation.
○ Ecotoxic effects: The product is not classified as Dangerous for the Environment.
13. Accidental release measures
○ Personal protection: Refer to section 8.
○ Environmental Precaution: Prevent product entering soil, natural waters and drains.
14. Disposal considerations
○ Waste product should not be discharged directly into drains or waterways without treatment.
○ Disposal of product and packaging should always comply with local and national regulations.
○ Waste water containing product should be treated in a separation and biological treatment plant.
15. Regulatory information
○ Labelling according to EU directive 1999/45/EC:
○ Symbol not subject to labelling.
○ National regulations:
● Germany: Water hazard
● Class: WGK = 1, VwVwS Annex 4
16. Other information
○ The information given here is to the best of our knowledge true and accurate and is provided solely for making safety assessments. It is not a sales specification or an indication of suitability for a particular use.
○ 5S-ROAD is manufactured in Saudi Arabia according to the formulations and specifications of 5S
